Product ID:NON-DETERGENT MOTOR OIL,ALL SAE GRADES,SAE 20 ND
MSDS Date:08/09/1994
FSC:9150
NIIN:01-079-8310
MSDS Number: CCLWP

Emergency Phone: 814-368-6111/800-424-9300(CHEMTREC)

Info Phone: 814-368-6111

Preparer: ROBERT KELLAM

Cage: 75273

Telephone: 814-368-6111

Cage: 75273

DEOBASE (DEODORIZED KEROSENE)

CAS: 8020-83-5

RTECS: HF9500000

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

ADDITIVES/ADDITIVE MIXTURES (TRADE SECRET)

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE- MAY CAUSE EYE AND SKIN IRRITATION. INHALATION OF
VAPORS/OIL MIST MAY CAUSE IRRITATION OF NOSE AND THROAT. MAY BE
HARMFUL IF INGESTED. ASPIRATION HAZA RD. CHRONIC- MAY CAUSE
DERMATITIS.
Explanation of Carcinogenicity:WARNING! USED MOTOR OILS WERE SHOWN TO
CAUSE SKIN CANCER WHEN REPEATEDLY APPLIED TO MICE WITHOUT CLEANING
SKIN.
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
ABDOMINAL PAIN, TEARING, HEADACHE
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
CONTAMINATED CLOTHING. WIPE OFF EXCESS. WASH SKIN WITH SOAP &
WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FR ESH AIR. PROVIDE OXYGEN/CPR IF NEEDED.
ORAL:GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:COC
Flash Point:>193.3C, 380.F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND MAY BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. REMOVE SPILL WITH
INERT ABORBENT SUCH AS SAND, CLAY, EARTH. TRANSFER TO PROPER
CONTAINERS FOR DISPOSAL. PREVENT RUN-OFF TO ENTER SEWERS OR
WATERWAYS. WASH AREA TO REMOVE TRA CE RESIDUE.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A DRY PLACE AWAY FROM OPEN
FLAMES AND STRONG OXIDIZING AGENTS. KEEP CONTAINER CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE. ALL PRECAUTIONS
SHOULD BE OBSERVED. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF
REACH OF CHILDREN. AVOID BREATHING MISTS/VAPORS. AVOID REPEATED
SKIN CONTACT. DO NOT GET IN EYES. DO NOT INGEST.

Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. IF
HIGH VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH APPROVED
CHEMICAL CARTRIDGE RESPIRATOR FOR ORGANIC VAPORS AND MISTS. REFER
TO 29 CFR 1910.134.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:NITRILE IF FREQUENT CONTACT EXPECTED
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A = B, SAME NSN.

HCC:V6
Boiling Pt:>329.4C, 625.F
Melt/Freeze Pt:<-12.2C, 10.F
Vapor Pres:0
Spec Gravity:0.86 - 0.89
Viscosity:>=100SUS@100F
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:0 AT 20C/68F
Appearance and Odor:DARK GREEN-BROWN LIQUID; MOTOR OIL ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS HYDROGEN PEROXIDE, BROMINE AND CHROMIC
ACID
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF PHOSPHORUS, OXIDES OF SULFUR

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND
FEDERAL REGULATIONS. PRODUCT IS AN OIL. SPILLS TO US SURFACE WATERS
OR WATERCOURSE OR SEWER THAT CAUSE A VISIBLE SHEEN MUST BE REPORTED
TO THE NATIONAL RE SPONSE CENTER. RCRA PHONE: 800-424-9346.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.